强激光与粒子束, 2011, 23 (12): 3265, 网络出版: 2012-01-04  

复合材料层合板在激光辐照下的应变测试与分析

Strain test and analysis of composite laminated plate under laser irradiation
作者单位
1 北京工业大学 机电学院, 北京 100124
2 北京工业大学 激光工程研究院, 北京 100124
摘要
对T300/AG80碳纤维复合材料层合板在激光辐照下的应变变化情况进行了测试。利用动态应变仪对不同半径激光光斑照射下的试件正面和背面的0°,45°,90°三个方向的应变进行记录,通过对消除温升影响后的试验数据进行分析得知:各处应变随测试点到光斑中心的距离增大而减小;0°方向应变最小,90°方向应变最大,光斑辐照层合板5 s时,90°方向应变值至少是0°方向应变值的1.5倍。采用有限元分析软件对试验过程进行模拟,光斑外各处热应力随其到光斑中心距离的增大而减小。将模拟中得到的应变与试验过程中的测试值对比,得到温升影响造成的最大相对误差为16.9%。
Abstract
The change in strain of T300/AG80 carbon fiber composite laminated plates were tested under laser irradiation. The strain in three directions of 0°,45° and 90° of the samples under laser beams with various radii were recorded by the dynamic strain testing apparatus. With the effects of temperature eliminated, the presented data show that, the strain decreases with the increase of the distance to the center of laser spot. After the laminates are irradiated for 5 seconds, the maximum strain is found in the direction of 90° and is at least 1.5 times larger than the minimum strain in the direction of 0°. The thermal stress at every point decreases as the distance to the spot center increases. The experiment process was simulated with finite element analysis software, which shows that the maximum relative error caused by temperature is 16.9%.
参考文献

[1] 陈平, 于祺, 孙明, 等. 高性能热塑性树脂基复合材料的研究进展[J]. 纤维复合材料, 2005(2): 52-57.(Chen Ping, Yu Qi, Sun Ming, et al. Advances in high performance FRTP composites.Fiber Composites,2005(2): 52-57)

[2] 陈洁, 熊翔, 肖鹏. 高导热C/C复合材料的研究进展[J]. 材料导报, 2006,20(7): 431-435.(Chen Jie, Xiong Xiang, Xiao Peng. Research and development of high-thermal conductivity carbon/carbon composites.Mater Rev,2006,20(7): 431-435)

[3] Rodden W S O, Kudesia S S, Hand D P, et al. A comprehensive study of the long pulse Nd: YAG laser drilling of multi-layer carbon fibre composites[J].Optics Communications,2002,210(3/6): 319-328.

[4] Hirogaki T, Aoyama E, Inoue H, et al. Laser drilling of blind via holes in aramid and glass/epoxy composites of multi-layer printed wiring boards[J].Composites,2001,32(7): 963-968.

[5] Young T, O’Driscoll D. Impact of ND-YAG laser drilled holes on the strength and stiffness of laminar flow carbon fibre reinforced composite panels[J].Composite,2002,33(1): 1-9.

[6] Lachaud J, Aspa Y, Vignoles G. Analytical modeling of the steady state ablation of a 3D C/C composite[J].International Journal of Heat and Mass Transfer,2008,51(9/10): 2614-2627.

[7] Pan C T, Hocheng H. The anisotropic heat-affected zone in the laser grooving of fiber-reinforced composite material[J].Journal of Materials Processing Technology,1996,62(1/3): 54-60.

[8] 黄国君, 杨治星, 段祝平. 激光-载荷联合作用下碳纤维/环氧树脂板的断裂阈值研究[J]. 强激光与粒子束, 1999,11(6): 677-681.(Huang Guojun, Yang Zhixing, Duan Zhuping. Investigation on the fracture threshold of woven carbon-fiber/epoxy plates under mechanical loading and heating by incident laser beams.High Power Laser and Particle Beams,1999,11(6): 677-681)

[9] 陈明, 龙连春, 刘世炳, 等. 激光辐照与拉伸预应力作用下复合材料试件的破坏研究[J]. 应用力学学报, 2010,27(2): 412-417.(Chen Ming, Long Lianchun, Liu Shibing, et al. Destruction of composite material under tensile pre-stressing and laser irradiation.Chinese Journal of Applied Mechanics,2010,27(2): 412-417)

[10] 王贵兵, 刘仓里. 芳纶纤维复合材料对激光的吸收特性研究[J]. 强激光与粒子束, 2003,15(11): 1065-1067.(Wang Guibing, Liu Cangli. Absorption characteristics of the composite reinforced by polyaryl amide fibers irradiated by high power laser.High Power Laser and Particle Beams,2003,15(11): 1065-1067)

[11] 张永强, 王伟平, 唐小松, 等. 两种纤维增强复合材料与连续激光耦合规律[J]. 强激光与粒子束, 2007,19(10): 1599-1602.(Zhang Yongqiang, Wang Weiping, Tang Xiaosong, et al. Coupling rules of two fiber reinforced composites with continuous wave laser.High Power Laser and Particle Beams,2007,19(10): 1599-1602)

[12] 张剑, 李思简. 复合材料大层数层合板热变形热应力有限元分析[J]. 固体力学学报, 1997,18(4): 359-364.(Zhang Jian, Li Sijian. Thermal stress of composite laminated structure with a large number of layers.Acta Mechanica Solida Sinica,1997,18(4): 359-364)

[13] 丁升, 王建国, 王玉恒, 等. 激光辐照热力耦合问题的相似性[J]. 强激光与粒子束, 2005,17(9): 1331-1334.(Ding Sheng, Wang Jianguo, Wang Yuheng, et al. Similarity of thermo-mechanical effect induced by high energy laser beam.High Power Laser and Particle Beams,2005,17(9): 1331-1334)

[14] 陈明. 激光辐照下复合材料结构的响应分析与试验测试[D]. 北京: 北京工业大学, 2010: 13-14.(Chen Ming. Response analysis and experimental test of composite structure irradiated by laser. Beijing: Beijing University of Technology, 2010: 13-14)

[15] 张骏华, 盛祖明, 孙继桐. 导弹和运载火箭复合材料结构设计指南[M]. 北京: 中国宇航出版社, 1999: 14-35.(Zhang Junhua, Sheng Zuming, Sun Jitong. Missile and launch vehicle composite structure design guidelines. Beijing: China Astronautic Publishing House, 1999: 14-35)

[16] 尹福炎. 瞬态加热条件下高温应变计测量误差修正方法[J]. 强度与环境, 2005,32(1): 36-42.(Yin Fuyan. Correction technique for high temperature strain gage under transient heating conditions.Structure and Environment Engineering,2005,32(1): 36-42)

朱凯, 龙连春, 陈明, 刘世炳. 复合材料层合板在激光辐照下的应变测试与分析[J]. 强激光与粒子束, 2011, 23(12): 3265. Zhu Kai, Long Lianchun, Chen Ming, Liu Shibing. Strain test and analysis of composite laminated plate under laser irradiation[J]. High Power Laser and Particle Beams, 2011, 23(12): 3265.

关于本站 Cookie 的使用提示

中国光学期刊网使用基于 cookie 的技术来更好地为您提供各项服务,点击此处了解我们的隐私策略。 如您需继续使用本网站,请您授权我们使用本地 cookie 来保存部分信息。
全站搜索
您最值得信赖的光电行业旗舰网络服务平台!