激光与光电子学进展, 2017, 54 (4): 041412, 网络出版: 2017-04-19  

激光扫描加热铸轧辊套材料热疲劳性能测试 下载: 549次

Thermal Fatigue Performance Test of Casting Roller Sleeve Material Heated by Laser Scanning
作者单位
中国科学院力学研究所先进制造工艺力学重点实验室, 北京 100190
摘要
以Nd∶YAG连续激光为热源,激光扫描加热铸轧辊套材料32Cr3Mo1V表面,接触冷却样品背面,进行了热疲劳性能测试。用集**数法测量了不同表面粗糙度和氧化状态下材料的激光吸收率,并数值计算模拟了样品表面的温度循环和压应力状态。结果显示,热循环1000周次后,在样品表面烧蚀坑和粗大磨痕处均出现裂纹。1000~2000周次热循环范围内,裂纹长度与热循环次数呈线性关系。由于测试中忽略了铝铸轧过程中辊套承受的机械应力和铝液对辊套的作用,测得的辊套裂纹扩展速率为实际值的一半。
Abstract
By using Nd∶YAG continuous laser as the heat resource to scan and heat the surface of the casting roller sleeve material 32Cr3Mo1V, the thermal fatigue performance is tested by contact cooling the back of the sample. The laser absorptivity of the sample with different surface roughness and oxidation state is measured with the lumped parametric method. The temperature cycle and compressive stress condition of the sample surface are simulated by numerical calculation. The results show that, after 1000 thermal cycles, cracks appear in the ablation hole and at positions with rough scratches on the sample surface. When the thermal cycle ranges from 1000 to 2000, the length of the crack is linearly related to the number of thermal cycles. Because the proposed method ignores the effects of mechanical stress and aluminum liquid on the roller sleeve, the growth rate of the crack length obtained from the test is only half of the actual one.
参考文献

[1] 平修二. 热应力与热疲劳(基础理论与设计应用)[M]. 郭廷伟, 李安定, 译. 北京: 国防工业出版社, 1984.

[2] 李福海, 佟 鑫, 刘 敏, 等. 32Cr3Mo1V表面激光合金化层热疲劳性能的研究[J]. 材料研究与应用, 2011, 5(2): 97-104.

    Li Fuhai, Tong Xin, Liu Min, et al. Thermal fatigue resistance of laser surface alloying layers on the surface of 32Cr3Mo1V substrate[J]. Materials Research and Application, 2011, 5(2): 97-104.

[3] Kundalkar D, Mavalankar M, Tewari A, et al. Effect of gas nitriding on the thermal fatigue behavior of martensitic chromium hot-work tool steel[J]. Materials Science and Engineering A, 2016, 651: 391-398.

[4] Birol Y. Thermal fatigue testing of Inconel 617 and Stellite 6 alloys as potential tooling materials for thixoforming of steels[J]. Materials Science and Engineering A, 2010, 527(7-8): 1938-1945.

[5] Fantini V, Serri L, Bianchi P. Laser thermal shock and fatigue testing system[C]. SPIE, 1997, 3097: 538-545.

[6] Rettig U, Bast U, Steiner D, et al. Characterization of fatigue mechanisms of thermal barrier coatings by a novel laser-based test[C]. The International Gas Turbine and Aeroengine Congress and Exhibition, Stockholm, 1998: 1-8.

[7] Kutsuna M, Fujita S, Sugita Y, et al. Thermal fatigue test for turbine housing by a pulse YAG Laser[C]. SPIE, 2000, 3888: 438-445.

[8] 贾 力, 孙智刚. 激光热疲劳实验系统在预测轧辊热疲劳性能上的研究[J]. 工业加热, 2009, 38(5): 63-64.

    Jia Li, Sun Zhigang. Investigation on laster system used on forecasting thermal fatigue performance of roll[J]. Industrial Heating, 2009, 38(5): 63-64.

[9] 景 勤, 赵 亮, 苑 辉, 等. 激光脉冲加热条件下Zr基非晶合金晶化及热疲劳行为[J]. 中国科学: 物理学 力学 天文学, 2010, 40(6): 706-710.

[10] 宋宏伟, 虞 钢, 王立新, 等. 激光诱发活塞的热负荷[J]. 中国激光, 2006, 33(5): 701-704.

    Song Hongwei, Yu Gang, Wang Lixin, et al. Laser-induced thermal loadings on pistons[J]. Chinese J Lasers, 2006, 33(5): 701-704.

[11] 宋宏伟, 李少霞, 虞 钢. 基于数值模拟的激光热负荷光强分布设计[J]. 中国激光, 2006, 33(6): 842-845.

    Song Hongwei, Li Shaoxia, Yu Gang. Intensity distribution design for laser-induced thermal loading based on numerical simulation[J]. Chinese J Lasers, 2006, 33(6): 842-845.

[12] 谭建松, 庞 铭, 解志民, 等. 活塞激光热负荷数值模拟[J]. 中国激光, 2010, 37(4): 970-974.

    Tan Jiansong, Pang Ming, Xie Zhimin, et al. Numerical simulation of thermal loading on piston by laser[J]. Chinese J Lasers, 2010, 37(4): 970-974.

[13] 庞 铭, 谭建松, 解志民. 活塞激光热负荷应力场数值模拟[J]. 光学与光电技术, 2011, 9(1): 17-20.

    Pang Ming, Tan Jiansong, Xie Zhimin. Numerical simulation of stress field for laser thermal loading of piston[J]. Optics and Optoelectronic Technology, 2011, 9(1): 17-20.

[14] 聂树真, 孙 辉, 虞 钢, 等. 非对称非均匀分布整形光束用于激光热负荷试验研究[J]. 激光与光电子学进展, 2015, 52(9): 091408.

    Nie Shuzhen, Sun Hui, Yu Gang, et al. Study on laser thermal loadingtest with non-symmetric and non-uniform shaped laser beam[J]. Laser & Optoelectronics Progress, 2015, 52(9): 091408.

[15] Song H W, Yu G, Tan J S, et al. Thermal fatigue on pistons induced by shaped high power laser. Part I: Experimental study of transient temperature field and temperature oscillation[J]. International Journal of Heat and Mass Transfer, 2008, 51(3-4): 757-767.

[16] 吴维泽. 提高铸轧辊套寿命的研究[D]. 沈阳: 东北大学, 2005: 29.

    Wu Weize. Research on the raising the life of the casting roll shell[D]. Shenyang: Northeastern University, 2005: 29.

[17] 蔺秀川, 邵天敏. 利用集总参数法测量材料对激光的吸收率[J]. 物理学报, 2001, 50(5): 854-859.

    Lin Xiuchuan, Shao Tianmin. Lumped method for the measurement of laser absorptance of materials[J]. Acta Physica Sinica, 2001, 50(5): 854-859.

[18] 崔春阳, 吴 炜, 虞 钢, 等. 球墨铸铁材料对激光的吸收率[J]. 中国激光, 2006, 33(7): 977-980.

    Cui Chunyang, Wu Wei, Yu Gang, et al. On laser absorptivity of ductile iron[J]. Chinese J Lasers, 2006, 33(7): 977-980.

[19] 李善德. 铸轧辊辊套热结构耦合分析及其疲劳寿命研究[D]. 长沙: 中南大学, 2006: 22.

    Li Shande. Thermal structural coupling and the fatigue life of the roll shell[D]. Changsha: Central South University, 2006: 22.

刘晓博, 王之桐, 李文. 激光扫描加热铸轧辊套材料热疲劳性能测试[J]. 激光与光电子学进展, 2017, 54(4): 041412. Liu Xiaobo, Wang Zhitong, Li Wen. Thermal Fatigue Performance Test of Casting Roller Sleeve Material Heated by Laser Scanning[J]. Laser & Optoelectronics Progress, 2017, 54(4): 041412.

关于本站 Cookie 的使用提示

中国光学期刊网使用基于 cookie 的技术来更好地为您提供各项服务,点击此处了解我们的隐私策略。 如您需继续使用本网站,请您授权我们使用本地 cookie 来保存部分信息。
全站搜索
您最值得信赖的光电行业旗舰网络服务平台!