红外与激光工程, 2018, 47 (7): 0717003, 网络出版: 2018-08-30  

光电复合海缆温度场建模分析及在在线监测中的应用

Analysis of temperature field model in optic-electric composite submarine cable and its applications in online monitoring
作者单位
1 华北电力大学 河北省输变电设备安全防御重点实验室, 河北 保定 071003
2 华北电力大学 电子与通信工程系, 河北 保定 071003
摘要
为了有效监测光电复合海缆的绝缘状况, 基于迭代法改进了IEC60287电缆载流量和温度场计算标准, 在有限元数值分析软件包COMSOL中基于热电耦合模块建立了110 kV YJQ41×300 mm2海缆温度场模型, 与改进IEC60287标准比较验证了建模方法的准确性, 在此基础上确定了不同载流量下海缆模型最佳的分析范围。建模研究了海缆正常运行和绝缘性能下降情况下载流量和环境温度对光纤温升的影响; 采用介质损耗表征绝缘状况, 分析获得了典型介损值下光纤相对温升的变化规律。结果表明: 正常情况下光纤温升随载流量的增加近似成平方增大, 随环境温度的增加近似线性增大, 增速较慢; 海缆绝缘性能下降时光纤相对温升随tanδ的增加成正比增大, 相对而言, 受环境温度的影响很小。根据上述研究, 提出了基于光纤相对温升和海缆载流量的介损计算公式和基于光纤相对温升的海缆绝缘状态监测方法。较之现有基于电气量的绝缘监测方法, 该方法不易遭受电磁干扰的影响。在光电复合海缆在线监测方面具有参考应用价值。
Abstract
To effectively monitor the insulation state of the optic-electric composite submarine cable, the IEC60287 cable′ ampacity and temperature calculation standard were improved by iteration algorithm and the temperature field model of 110 kV YJQ41×300 mm2 submarine cable was established with the finite element analysis, solver and simulation software package COMSOL based on the thermoelectric coupling model. The results were validated by the improved IEC60287 and the optimal model size of the submarine cable at different values of ampacity was obtained. The effects of ampacity and ambient temperature on the optical fiber′s temperature rise were investigated in normal insulation state and at different levels of insulation degradation of the submarine cable. Dielectric loss factor was used to characterize the insulation states, the change of optical fiber′s relative temperature rise under the typical value of dielectric loss factor was investigated. The results reveal that, under normal circumstances, the temperature rise of fiber is approximately proportional to the square of ampacity and it increases approximately linearly with increasing ambient temperature with a slow velocity. When the cable′s insulation degraded, the relative temperature rise of the optical fiber is proportional to the tanδ. Comparatively, the ambient temperature has little influence on it. According to above research, a formula for estimation of dielectric loss factor based on relative temperature rise and ampacity of cable is presented and a method for insulation degradation evaluation of the submarine cable based on relative temperature rise of optical fiber is proposed. Compared with the existing insulation monitoring methods based on electrical measurands, the error caused by electromagnetic interference can be avoided in proposed method, which can be applied in the online monitoring of the optic-electric composite submarine cable.
参考文献

[1] Orton H. Power cable technology review[J]. High Voltage Engineering, 2015, 41(4): 1057-1067.

[2] Li Wei, Wu Linlin, Zhang Xing, et al. Research progress in aging and evaluation of XLPE cable[J]. Insulating Materials, 2016, 49(11): 36-44. (in Chinese)

[3] Xu Jun, Wang Xiaodong, Ouyang Benhong, et al. Effect of thermal aging on physical and chemical structure of XLPE cable insulation [J]. Insulating Materials, 2013, 46(2): 33-37. (in Chinese)

[4] International Electrotechnical Commission. IEC60287-1 Calculation of the current rating-part 1: current rating equations (100% load factor) and calculation of losses [S]. 2006: 11-25.

[5] Wang Youyuan, Chen Rengang, Chen Weigen, et al. Calculation of static temperature field of buried cable based on FEM and analysis of influential factors [J]. High Voltage Engineering, 2009, 35(12): 3086-3092. (in Chinese)

[6] Karahan M, Kalenderli O. Coupled Electrical and Thermal Analysis of Power Cables Using Finite Element Method [M]. US: InTech, 2011: 206-230.

[7] Lv Anqiang. Research on condition monitoring of optical fiber composite submarine power cable based on bistributed strain and temperature sensing technology using optical fiber [D]. Beijing: North China Electric Power University, 2015: 57-61. (in Chinese)

[8] Worzyk T. Submarine Power Cables: Design, Installation, Repair, Environmental Aspects [M]. Berlin: Springer Science & Business Media, 2009.

[9] Naskar A K, Bhattacharya N K, Saha S, et al. Thermal analysis of underground power cables using two dimensional finite element method [C]//2013 International Conference on Condition Assessment Techniques in Electrical Systems, IEEE, 2014, 2: 94-99.

[10] Toliyat H A, Nandi S, Choi S, et al. Electric Machines: Modeling, Condition Monitoring, and Fault Diagnosis [M]. Abingdon: Taylor & Francis, 2012.

[11] Zhao Lijuan, Li Yongqian, Xu Zhiniu, et al. Online monitoring system of 110 kV submarine cable based on BOTDR [J]. Sensors and Actuators A: Physical, 2014, 216(3): 28-35.

[12] Lv Anqiang, Li Yongqian, Li Jing, et al. Strain and temperature monitoring of 110 kV optical fiber composite submarine power cable based on Brillouin optical time domain reflectometer [J]. High Voltage Engineering, 2014, 40(2): 533-539. (in Chinese)

[13] Zhao Lijuan, Li Yongqian, Xu Zhiniu. Influence of optimization model on parameter extraction in Lorentzian Brillouin scattering spectrum[J]. Infrared and Laser Engineering, 2016, 45(5): 0522002. (in Chinese)

[14] Baazzim M S, Alsaud M S, Elkady M A. Comparison of finite-element and IEC methods for cable thermal analysis under various operating environments [J]. International Journal of Electrical, Computer, Energetic, Electronic and Communication Engineering, 2014, 8(3): 470-475.

[15] Mecheri Y, Boukezzi L, Boubakeur A, et al. Dielectric and mechanical behavior of cross-linked polyethylene under thermal aging[C]//2000 Annual Report Conference on Electrical Insulation and Dielectric Phenomena, IEEE, 2000: 884022.

[16] Soma K, Aihara M, Kataoka Y. Diagnostic method for power cable insulation[J]. IEEE Transactions on Electrical Insulation, 1986, 21(6): 1027-1032.

[17] Zhang Hailong. 110-220 kV XLPE cable insulation on-line monitoring technique [D]. Wuhan: Wuhan University, 2009. (in Chinese)

[18] Wang Hongxin, Cheng Shukang, Wen Xishan, et al. AC insulation characteristics of XLPE in the course of aging [J]. High Voltage Engineering, 2005, 31(3): 7-9. (in Chinese)

徐志钮, 胡志伟, 赵丽娟, 李永倩, 张翼, 胡世勋. 光电复合海缆温度场建模分析及在在线监测中的应用[J]. 红外与激光工程, 2018, 47(7): 0717003. Xu Zhiniu, Hu Zhiwei, Zhao Lijuan, Li Yongqian, Zhang Yi, Hu Shixun. Analysis of temperature field model in optic-electric composite submarine cable and its applications in online monitoring[J]. Infrared and Laser Engineering, 2018, 47(7): 0717003.

关于本站 Cookie 的使用提示

中国光学期刊网使用基于 cookie 的技术来更好地为您提供各项服务,点击此处了解我们的隐私策略。 如您需继续使用本网站,请您授权我们使用本地 cookie 来保存部分信息。
全站搜索
您最值得信赖的光电行业旗舰网络服务平台!