强激光与粒子束, 2014, 26 (12): 123006, 网络出版: 2015-01-08  

金属掺杂钨基合金阴极的二次电子发射系数研究

Secondary electron emission coefficient of metal doping W-base alloy cathode
作者单位
1 中国科学院 电子学研究所, 中国科学院高功率微波源与技术重点实验室, 北京 100190
2 中国科学院大学, 北京 100039
摘要
实验中制备了W-Re,W-Sc,W-Zr,W-Y合金阴极,其中Re,Sc,Zr,Y元素所占合金阴极材料的质量分数都为5%。二次电子发射系数测试结果显示,Re掺杂合金阴极对提高纯钨阴极二次电子发射能力显著,掺杂5% Re的W-Re合金阴极材料具有最大二次电子发射系数,其值为1.8,相比于纯钨阴极,能够提高80%。鉴于Re对提高纯钨阴极二次电子发射能力显著,对Re掺杂质量分数分别为20%,10%,6%,5%,4%,3%W-Re合金阴极材料二次电子发射系数进行了研究,发现随着Re在W-Re合金阴极材料中含量的降低,其二次电子发射系数在不断增大,仅当Re含量下降至5%左右时,合金阴极具有最大二次电子发射系数,继续下降至4%,合金阴极二次电子发射系数不但没有升高,相反下降至1.41,当下降至3%时,合金阴极二次电子发射系数值迅速降低为1.1。
Abstract
W-Re, W-Sc, W-Zr, W-Y metal alloy cathodes were prepared, with Re, Sc, Zr and Y in metal alloy cathodes having the same mass fraction of 5%. Secondary electron emission coefficient testing results show that Re doped metal alloy cathodes can enhance the coefficient of pure W cathode sintered with W powder in the same preparation environment remarkably. 20%, 10%,6%, 5%, 4% and 3% mass fraction Re doped metal alloy cathodes were researched. 5% Re doped W-Re metal alloy cathode has the biggest maximum secondary electron emission coefficient of 1.8, 80% higher than that of pure W cathode. With the mass fraction of Re reducing, the coefficient of metal alloy cathodes were rising. When the mass fraction of Re dropped to 5%, metal alloy cathode had the biggest coefficient. However, for the mass fraction 4% of Re, the maximum coefficient of the metal alloy cathode dropped to 1.41. For the mass fraction 3% of Re, the maximum coefficient of metal alloy cathodes was only 1.1.
参考文献

[1] Wang Xiaoxia, Liao Xianheng, Luo Jirun, et al. Study on the Ni-Re-Ir sponge oxide cathode[J]. IEEE Trans on Electron Devices, 2012, 59(2):491-495.

[2] Zhang Min, Wang Xiaoxia, Luo Jirun, et al, Influence of plasma spraying on the performance of oxide cathodes[J]. IEEE Trans on Electron Devices, 2011, 58(7):2143-2147.

[3] 杨安民,夏连胜,王辉,等.大直径钪酸盐阴极发射特性[J].强激光与粒子束, 2011, 23(6):1621-1624.(Yang Anming, Xia Liansheng, Wang Hui, et al. Emission characteristic of scandate cathode with large diameter. High Power Laser and Particle Beams, 2011, 23(6):1621-1624)

[4] Insepov Z, Ivanov V, Frisch H. Comparison of candidate secondary electron emission materials[J]. Nuclear Instruments and Methods in Physics Research B, 2010, 268:3315-3320.

[5] 雷文强,郭焱华,宋睿,等.非均匀磁场下14叶片5.8 GHz磁控管的三维数值模拟[J].强激光与粒子束, 2013, 25(11):2922-2926.(Lei Wenqiang, Guo Yanhua, Song Rui, et al. 3-D simulation of 14 vanes 5.8 GHz magnetrons in non-uniform magnetic field. High Power Laser and Particle Beams, 2013, 25(11):2922-2926)

[6] 裘家琪,陈怀璧,唐传祥.衰减瓷对同轴磁控管起振过程的影响[J].强激光与粒子束, 2012, 24(12):2879-2882.(Qiu Jiaqi, Chen Huaibi, Tang Chuanxiang. Effect of attenuator on oscillating process of coaxial magnetrons. High Power Laser and Particle Beams, 2012, 24(12):2879-2882)

[7] 电子管设计手册编辑委员会.磁控管设计手册[M].北京:国防工业出版社, 1979:192-194.(Editorial Committee of Electronic Tube Design Handbook. Magnetron Design Handbook. Beijing: National Defense Industry Press, 1979:192-194)

[8] Wang Jinshu, Liu Wei, Ren Zhiyuan, et al. Enhancement of secondary emission property of molybdenum cathode co-doped with La2O3 and Y2O3[J]. Journal of Rare Earth, 2009, 27(6):975-979.

[9] Wang Jinshu, Ren Zhiyuan, Liu Wei, et al. Effects of RE2O3 doping on the reduction behavior of molybdenum oxide and properties of molybdenum powder[J]. Journal of Refractory Metals and Hard Materials, 2009, 27:155-158.

[10] Wang Jinshu, Wang Yiman, Zhou Meiling, et al. Anti-bombing insensitivity life of molybdenum cathode doped with La2O3 and Y2O3[J]. Materials Science and Engineering B, 2006, 128:211-215.

[11] Djubua B C, Kultashev O K, Makarov A P, et al. Metal alloy cathodes for application in vacuum microwave devices[C]//IEEE International Vacuum Electron Conference. 2012:177-178.

[12] Djubua B C, Makarov A P, Negirev A A, et al. Metal alloy cathodes for very high emission- density applications[C]//IEEE International Vacuum Electron Conference. 2010:155-156.

[13] Djubua B C, Polivnikova O V. Stratum-like structured metal alloy cathode[J]. Applied Surface Science, 2003, 215:242-248.

[14] 李玉涛,张洪来,刘濮鲲,等.中间层Re的加入对覆膜钡钨阴极性能的改善[J].物理学报, 2006, 55(12):6677-6682.(Li Yutao, Zhang Honglai, Liu Pukun, et al. Improved performance of the dispenser cathode with a Re intermediate layer. Acta Physica Sinica, 2006, 55(12):6677-6682)

[15] Wang Jinshu, Li Lili, Liu Wei, et al. Preparation and characterization of scandia and Re doped tungsten matrix impregnated cathode[J]. Physics and Chemistry of Solids, 2007, 68:2209-2215.

漆世锴, 王小霞, 罗积润, 赵世柯, 李云, 赵青兰. 金属掺杂钨基合金阴极的二次电子发射系数研究[J]. 强激光与粒子束, 2014, 26(12): 123006. Qi Shikai, Wang Xiaoxia, Luo Jirun, Zhao Shike, Li Yun, Zhao Qinlan. Secondary electron emission coefficient of metal doping W-base alloy cathode[J]. High Power Laser and Particle Beams, 2014, 26(12): 123006.

关于本站 Cookie 的使用提示

中国光学期刊网使用基于 cookie 的技术来更好地为您提供各项服务,点击此处了解我们的隐私策略。 如您需继续使用本网站,请您授权我们使用本地 cookie 来保存部分信息。
全站搜索
您最值得信赖的光电行业旗舰网络服务平台!