非离子型表面活性剂Tween20对大尺寸双层空心微球制备的影响

苏琳; 李洁; 初巧妹; 刘一杨; 刘梅芳; 李婧; 张占文; 李波

doi:doi:10.11884/hplpb201527.122007

强激光与粒子束, 2015, 27 (12): 122007, 网络出版: 2015-12-18

非离子型表面活性剂Tween20对大尺寸双层空心微球制备的影响

Effect of Tween 20 nonionic surfactant on preparation of large size double-layer hollow microspheres

论文大纲

苏琳 ^*李洁初巧妹刘一杨刘梅芳李婧张占文李波

作者单位

中国工程物理研究院激光聚变研究中心, 四川绵阳 621900

摘要

为了改善臭氧处理聚苯乙烯(PS)单层球与聚乙烯醇(PVA)溶液生成的双层乳粒在油相中的分散性,提高大尺寸双层球的成活率,在双层球制备过程中采用了非离子型表面活性剂Tween 20 (T-20)来改性该种PS单层球。结果表明经表面活性剂T-20改性后显著降低了PS薄膜的亲水接触角,提高了PS与PVA间的相互作用,同时也大幅度提高了PS薄膜对PVA的吸附速率。红外光谱和紫外-可见分光光度计的测试结果证明：在PVA固化过程中,由于PVA与T-20的相比太大,PS表面吸附的表面活性剂T-20部分会被PVA置换、迁移至PVA溶液中。 T-20的迁移提高了制备双层球过程中水相与外油相的粘度比且显著降低PVA溶液表面张力,从而有利于实现双重乳粒在油相中的单分散。因此,T-20是制备大尺寸PS-PVA双层空心微球有效的表面活性剂。

Abstract

The investigation of the preparation technique of polymeric hollow microsphere is very important for the fuel container of inertial confinement fusion (ICF). The 1% of Tween 20 (T-20) nonionic surfactant is used to modify ozonated polystyrenes microspheres to improve the dispersion of the polystyrene-polyvinylalcohol (PS-PVA) double-layer emulsion microspheres in oil phase and to enhance the survival rate of large size double microspheres. The T-20 treated PS single-layer microspheres are subsequently immersed into PVA solution and encapsulated by PVA. Then the curing technique is used to ensure the fabrication of monodispersed PS-PVA double-layer emulsion microspheres. The results reveal that the contact angle of PS film can be obviously decreased due to the T-20 surface modification of PS. In addition, both the interaction between PS and PVA and the absorption rate of PS film to PVA are greatly enhanced. The infrared spectroscopy and ultraviolet spectroscopy results show that part of absorbed T-20 surfactant on PS surface is replaced by PVA and immigrates into PVA solution in the curing procedure of PVA because of the large dimension of PVA macromolecular. The immigration of T-20 results in the increase of the viscosity ratio of water phase to oil phase and the obviously decrease of the surface tension for PVA during the process of fabricating double-layer emulsion microspheres. The dispersion of PS-PVA double microspheres in oil phase is also improved. The survival rate of large size double-layer hollow microspheres after modified by T-20 remarkably increases to 50%. Therefore, the T-20 is efficient nonionic surfactant in preparing large size PS-PVA double-layer hollow microspheres.

参考文献

[1] Paguio R R, Frederick C A, Hund J F, et al. Fabrication capabilities for spherical foam targets used in ICF experiments［C］//17th Target Fabrication Specialist Meeting. 2006:1-5.

[2] 苏琳, 陈素芬, 刘梅芳,等. 塑料微球表面制备聚乙烯醇涂层研究进展［J］. 强激光与粒子束, 2012, 24(7): 1517-1522.

Su Lin, Chen Sufen, Liu Meifang, et al. Research progress about fabrication of poly (vinyl alcohol) coating on the surface of plastic microsphere. High Power Laser and Particle Beams, 2012, 24(7): 1517-1522

[3] Cox R G. The deformation of a drop in a general time-dependent fluid flow［J］. J Fluid Mech, 1969, 37(3) : 601-623.

[4] 刘一杨. 双层塑料空心微球制备与掺杂技术研究［D］.长春：吉林大学, 2011.

Liu Yiyang. Preparation of double-layer hollow plastic microspheres and doping research. Changchun: Jilin University, 2011

[5] Alan K B, John Z G, Eben M. Fabrication of polyvinyl alcohol coated polystyrene shells［J］. Journal of Vacuum Science and Technology, 1987, A5(6): 3417-3421.

[6] 刘一杨, 阚秋斌, 魏胜, 等. 臭氧化法表面改性聚苯乙烯薄膜［J］.强激光与粒子束,2011,23(1):111-114.

Liu Yiyang, Kan Qiubin, Wei Sheng, et al. Surface modification of PS films by ozone. High Power Laser and Particle Beams, 2011,23(1): 111-114

[7] 苏琳, 李婧, 李洁, 等. 臭氧改性及搅拌桨结构对大直径双层球制备的影响［J］. 强激光与粒子束, 2013, 25(12):3269-3273.

Su Lin, Li Jing, Li Jie, et al. The effect of surface modification by ozonization and structures of impeller in fabricating large-size double-layer hollow microspheres. High Power Laser and Particle Beams, 2013, 25(12):3269-3273.

[8] 肖进新, 赵振国. 表面活性剂应用原理［M］. 北京：化学工业出版社,2003. (Xiao Jinxin, Zhao Zhenguo. Application principle of surfactant. Beijing: Chemical Industry Press, 2003)

[9] 赵国玺.表面活性剂物理化学［M］.北京:北京大学出版社, 1984: 139-165. (Zhao Guoxi. Physical chemistry of surfactants. Beijing: Peking University Press. 1984: 139-165)

[10] Shukla D, Tyagi V K. Cationic Gemini surfactants: a review［J］. Journal of LOEO Science, 2006, 55(8):381-390.

[11] 苏琳, 李婧, 李洁, 等. 离子型表面活性剂对双重乳粒分散性能的影响［J］. 强激光与粒子束, 2014, 26:022012.

Su Lin, Li Jing, Li Jie, et al. Influence of ionic surface active agent on distribution properties of PS-PVA double emulsion. High Power Laser and Particle Beams, 2014, 26:022012

[12] 游毅, 邓永淑, 李二军, 等. Gemini 表面活性剂烷烃尾链在吸附和聚集过程中的疏水协同效应［J］. 物理化学学报, 2010, 26(8)：2200-2204.

You Yi, Deng Yongshu, Li Erjun, et al. Hydrophobic synergism between the Alkyl tails of Gemini surfactants during adsorption and aggregation. Acta Phys Chim Sin, 2010, 26(8)：2200-2204

[13] Zana R, Talmon Y. Dependence of aggregate morphology on structure of dimeric surfactants［J］. Nature, 1993, 362: 228.

[14] 刘芬, 谢丹华, 赵剑曦. 动态光散射研究盐对Gemini表面活性剂网状聚集体的影响［J］. 物理化学学报, 2014, 30(6):1142-1147.

Liu Fen, Xie Danhua, Zhao Jianxi. Salt effects on the network-like aggregates of Gemini surfactant studied by dynamic light scattering. Acta Phys Chim Sin,2014, 30(6):1142-1147

[15] 裴晓梅, 赵剑曦, 魏西莲. 水杨酸钠对阳离子Gemini表面活性剂水溶液中蠕虫状胶束形成和性质的影响［J］. 物理化学学报, 2011, 27 (4):913-917.

Pei Xiaomei, Zhao Jianxi, Wei Xilian. Effect of sodium salicylate on the formation and properties of wormlike micelles in aqueous cationic Gemini surfactant solutions. Acta Phys Chim Sin, 2011, 27(4): 913-917)

[16] Menger F M, Littau C A. Gemini-surfactants: synthesis and properties［J］. J Am Chem Soc, 1991,113:1451-1452.

[17] Jiang N, Li P, Wang Y, et al. Micellization of cationic Gemini surfactants with various counterions and their interaction with DNA in aqueous solution［J］. J Phys Chem B,2004,108(39):15385-15391.

[18] 赵国玺,朱瑶. 表面活性剂作用原理［M］. 北京：中国轻工业出版社,2003:163-174.

Zhao Guoxi, Zhu Yao. Principle of surfactant action. Beijing：Chinese Light Industry Press, 2003：163-174

[19] Xie Y J, Yu H Y, Xu Z K. Surface modification of polypropylene microporous membranes by the adsorption of non-ionic surfactants［J］. Chinese Journal of Polymer Science,2006, 24(4): 421-429.

[20] Woodward N C, Gunning A P, Mackie A R, et al. Comparison of the orogenic displacement of sodium caseinate with the caseins from the air-water interface by nonionic surfactants［J］. Langmuir, 2009,25(12):6739-6744.

[21] Dudley H W, Ian F. Spectroscopic methods in organic chemistry［M］. England: McGraw-Hill Publishing Company, 1995.

[22] 李昌厚. 紫外可见光光度计及其应用［M］. 北京: 化学工业出版社, 2010:8-14.

Li Changhou. Application of UV-VIS recording spectro photometer. Beijing: Chemical Industry Press, 2010:8-14

[23] Zhou G, Kresta S M. Correlation of mean drop size and minimum drop size with the turbulence energy dissipation and the flow in an agitated tank［J］. Chemical Engineering Science, 1998, 53(11): 2063-2079.

[24] Ha J K, Yang S M. Fluid dynamics of a double emulsion droplet in an electric field［J］. Physics of Fluids, 1999, 11(5): 1029-1041.

[25] Tasoglu S, Kaynak G, Szeri A J, et al. Impact of a compound droplet on a flat surface: A model for single cell epitaxy［J］. Physics of Fluid, 2010, 22: 082103.

[26] Gao P, Feng J J. Spreading and breakup of a compound drop on a partially wetting substrate［J］. Journal of Fluid Mechanics, 2011, 682: 415-433.

苏琳, 李洁, 初巧妹, 刘一杨, 刘梅芳, 李婧, 张占文, 李波. 非离子型表面活性剂Tween20对大尺寸双层空心微球制备的影响[J]. 强激光与粒子束, 2015, 27(12): 122007. Su Lin, Li Jie, Chu Qiaomei, Liu Yiyang, Liu Meifang, Li Jing, Zhang Zhanwen, Li Bo. Effect of Tween 20 nonionic surfactant on preparation of large size double-layer hollow microspheres[J]. High Power Laser and Particle Beams, 2015, 27(12): 122007.

非离子型表面活性剂Tween20对大尺寸双层空心微球制备的影响

关于本站 Cookie 的使用提示

全站搜索

非离子型表面活性剂Tween20对大尺寸双层空心微球制备的影响

相关论文

相关资讯

关于本站 Cookie 的使用提示

全站搜索