中国激光, 2017, 44 (4): 0402010, 网络出版: 2017-04-10   

17-4PH不锈钢表面激光熔覆Stellite6涂层组织及耐水蚀性能

Microstructure and Water Erosion Resistance Property of Stellite6 Coating by Laser Cladding on 17-4PH Stainless Steel Surface
作者单位
1 上海交通大学上海市激光制造与材料改性重点实验室, 上海 200240
2 上海电气电站设备有限公司上海汽轮机厂, 上海 200240
摘要
为提高17-4PH不锈钢的耐水蚀性能, 利用激光熔覆方法在其表面制备了Stelite6合金涂层。研究了涂层的微观组织形貌、相组成以及元素扩散行为, 分析了涂层的硬度分布和耐水蚀性能。结果表明, Stellite6涂层微观组织由平面晶、胞状和柱状晶、树枝晶以及等轴晶组成, 物相组成包括面心立方(FCC)结构的γ-Co固溶体和M23C6、Cr7C3、CoCx等, Fe、Co元素在基体和涂层间的扩散明显。Stellite6涂层的最高硬度为561 HV, 平均硬度约为基材的1.4倍。多道多层熔覆时, 搭接区存在软化现象, 横向硬度分布出现周期性波动。在压力为80 Mpa、温度为80 ℃、水流冲蚀时间为30 h的条件下, 基材表面发生了严重的材料破坏, 而Stellite6涂层表面基本保留了初始形貌, 涂层的耐水蚀性能相比基材的有了显著提高。
Abstract
In order to improve the water erosion resistance property of the 17-4PH stainless steel, Stellite6 alloy coating is prepared on the surface of 17-4PH stainless steel by laser cladding. The coating microstructure, phase composition and element diffusion are studied and the hardness distribution and water erosion resistance property of the coating are analyzed. The results show that the microstructure of the Stellite6 coating is composed of plane crystal, cellular and columnar crystal, dendrite, and equiaxed crystal. The phase consists of γ-Co solid solution with face centered cubic (FCC) structure, M23C6, Cr7C3, and CoCx. Fe and Co elements diffuse between the substrate and the coating layer obviously. The highest hardness of the Stellite6 coating is 561 HV, and its average hardness is about 1.4 times of that of the substrate. In the multi-channel and multi-layer cladding, softening phenomenon occurs in the overlapped regions and the transverse hardness of Stellite6 coating fluctuates periodically. Under the conditions of pressure being 80 Mpa, temperature being 80 ℃ and water erosion time being 30 h, the substrate surface is destroyed seriously. However, the Stellite6 coating surface basically retains the original appearance. It indicates that the water erosion resistance property of the coating has been significantly improved than that of the substrate.
参考文献

[1] Wang J, Zou H, Li C, et al. The effect of microstructural evolution on hardening behavior of type 17-4PH stainless steel in long-term aging at 350 ℃[J]. Materials Characterization, 2006, 57(4): 274-280.

[2] Raj S V, Ghosn L J, Lerch B A, et al. Mechanical properties of 17-4PH stainless steel foam panels[J]. Materials Science and Engineering: A, 2007, 456(1): 305-316.

[3] 刘志江, 刘向民, 李连相. 近年我国大型汽轮机末级长叶片的冲蚀损伤[J]. 动力工程, 2003, 23(1): 2201-2204.

    Liu Zhijiang, Liu Xiangmin, Li Lianxiang. Erosion damage of last stage long blade of large steam turbine in China in recent years[J]. Power Engineering, 2003, 23(1): 2201-2204.

[4] Shepeleva L, Medres B, Kaplan W D, et al. Laser induced Cu/alumina bonding: Microstructure and bond mechanism[J]. Surface and Coatings Technology, 2000, 125(1): 40-44.

[5] Oakley S Y, Nowell D. Prediction of the combined high-and low-cycle fatigue performance of gas turbine blades after foreign object damage[J]. International Journal of Fatigue, 2007, 29(1): 69-80.

[6] 朱蓓蒂, 张之栋. 汽轮机末级叶片的激光熔覆研究[J]. 中国激光, 1994, 21(6): 526-529.

    Zhu Beidi, Zhang Zhidong. Study on laser cladding of last stage blades of steam turbine[J]. Chinese J Lasers, 1994, 21(6): 526-529.

[7] 王东生, 田宗军, 沈理达, 等. 激光熔覆技术研究现状及其发展[J]. 应用激光, 2012, 32(6): 538-544.

    Wang Dongsheng, Tian Zongjun, Shen Lida, et al. Research status and development of laser cladding technology[J]. Application Laser, 2012, 32(6): 538-544.

[8] 李养良, 金海霞, 白小波, 等. 激光熔覆技术的研究现状与发展趋势[J]. 热处理技术与装备, 2009, 30(4): 1-5.

    Li Yangliang, Jin Haixia, Bai Xiaobo, et al. Research status and development trend of laser cladding technology[J]. Heat Treatment Technology and Equipment, 2009, 30(4): 1-5.

[9] Qiao Y F, Fischer T E, Dent A. The effects of fuel chemistry and feedstock powder structure on the mechanical and tribological properties of HVOF thermal-sprayed WC-Co coatings with very fine structures[J]. Surface and Coatings Technology, 2003, 172(1): 24-41.

[10] D′Oliveira A S C, da Silva P S C, Vilar R M. Microstructural features of consecutive layers of Stellite 6 deposited by laser cladding[J]. Surface and Coatings Technology, 2002, 153(2): 203-209.

[11] 段晓溪, 高士友, 顾勇飞, 等. 激光熔覆316L+SiC的强化机制和摩擦磨损性能研究[J]. 中国激光, 2016, 43(1): 0103004.

    Duan Xiaoxi, Gao Shiyou, Gu Yongfei, et al. Study on reinforcement mechanism and frictional wear properties of 316L-SiC mixed layer deposited by laser cladding[J]. Chinese J Lasers, 2016, 43(1): 0103004.

[12] 徐金涛, 李 安, 刘 栋, 等. 激光熔覆 Cr3Si/γ多相涂层耐蚀性和耐磨性研究[J]. 中国激光, 2016, 43(3): 0303006.

    Xu Jintao, Li An, Liu Dong, et al. Research on corrosion resistance and wear resistance of laser cladding Cr3Si/γ multi-phase coating[J]. Chinese J Lasers, 2016, 43(3): 0303006.

[13] 秦承鹏, 郑玉贵. 17-4PH 不锈钢表面激光熔覆钴基合金涂层的空蚀行为研究[J]. 腐蚀科学与防护技术, 2011, 23(3): 209-213.

    Qin Chengpeng, Zheng Yugui. Cavitation erosion behavior of a laser clad Co-based alloy on 17-4PH stainless steel[J]. Corrosion Science and Protection Technology, 2011, 23(3): 209-213.

[14] 杨玉玲, 董丹阳. 材料的激光表面改性技术及应用[M]. 北京: 化学工业出版社, 2013: 72-76.

    Yang Yuling, Dong Danyang. Laser surface modification technology and application of Materials[M]. Beijing: Chemical Industry Press, 2013: 72-76.

[15] 王志会, 王华明, 刘 栋. 激光增材制造 AF1410 超高强度钢组织与力学性能研究[J]. 中国激光, 2016, 43(4): 0403001.

    Wang Zhihui, Wang Huaming, Liu Dong. Microstructure and mechanical properties of AF1410 ultra-high strength steel using laser additive manufacture technique[J]. Chinese J Lasers, 2016, 43(4): 0403001.

[16] Gholipour A, Shamanian M, Ashrafizadeh F. Microstructure and wear behavior of stellite6 cladding on 17-4PH stainless steel[J]. Journal of Alloy and Compounds, 2011, 509(14): 4905-4909.

[17] 王明瑜. B2 模具钢激光熔覆层微观组织与疲劳性能的研究[D]. 长春: 吉林大学, 2015: 25-26.

    Wang Mingyu. Study on the microstructure and fatigue properties of B2 mould steel laser cladding layer[D]. Changchun: Jilin University, 2015: 25-26.

[18] Woodford D A. Cavitation-erosion-lnduced phase transformations in alloys[J]. Metallurgical Transactions, 1972, 3(5): 1137-1145.

任超, 李铸国, 疏达, 赵文雨, 杨仁杰, 王朋, 叶建水. 17-4PH不锈钢表面激光熔覆Stellite6涂层组织及耐水蚀性能[J]. 中国激光, 2017, 44(4): 0402010. Ren Chao, Li Zhuguo, Shu Da, Zhao Wenyu, Yang Renjie, Wang Peng, Ye Jianshui. Microstructure and Water Erosion Resistance Property of Stellite6 Coating by Laser Cladding on 17-4PH Stainless Steel Surface[J]. Chinese Journal of Lasers, 2017, 44(4): 0402010.

本文已被 8 篇论文引用
被引统计数据来源于中国光学期刊网
引用该论文: TXT   |   EndNote

相关论文

加载中...

关于本站 Cookie 的使用提示

中国光学期刊网使用基于 cookie 的技术来更好地为您提供各项服务,点击此处了解我们的隐私策略。 如您需继续使用本网站,请您授权我们使用本地 cookie 来保存部分信息。
全站搜索
您最值得信赖的光电行业旗舰网络服务平台!