C-Fe谱线干扰修正对飞灰含碳量LIBS测量的影响

在燃煤电厂, 飞灰含碳量是直接反映锅炉燃烧效率的重要指标, 控制含碳量水平和低氮燃烧之间的平衡要求实现含碳量的在线(或快速)检测。将激光诱导击穿光谱技术应用于飞灰含碳量的快速测量, 针对测量中248 nm附近的C和Fe谱线干扰问题, 提出了利用Fe谱线修正的方法以提取重叠峰中C谱线的积分强度, 对比分析了Fe 248.33 nm, Fe 254.60 nm和 Fe 272.36 nm谱线分别作为Fe 247.98 nm的修正谱线时提取的C修正积分强度对飞灰含碳量定标曲线和未知样品重复测量精确度的影响。研究结果表明, 对C和Fe谱线干扰进行强度修正可以提高含碳量定标曲线的拟合度, 并且可以显著改善低含碳量样品重复测量的精确度。但同时需要注意用于修正的Fe谱线的合理选取, 防止在对低含碳量样品中C谱线强度的过度修正。从定标曲线和重复测量精确度总体评价而言, Fe 254.60 nm谱线最适用于LIBS测量飞灰含碳量时的C和Fe谱线干扰的修正。

Abstract

In coal-fired plants, Unburned carbon (UC) in fly ash is the major determinant of combustion efficiency in coal-fired boiler. The balance between unburned carbon and NOx emissions stresses the need for rapid and accurate methods for the measurement of unburned carbon. Laser-induced breakdown spectroscopy (LIBS) is employed to measure the unburned carbon content in fly ash. In this case, it is found that the C line interference with Fe line at about 248 nm. The interference leads to C could not be quantified independently from Fe. A correction approach for extracting C integrated intensity from the overlapping peak is proposed. The Fe 248.33 nm, Fe 254.60 nm and Fe 272.36 nm lines are used to correct the Fe 247.98 nm line which interference with C 247.86 nm, respectively. Then, the corrected C integrated intensity is compared with the uncorrected C integrated intensity for constructing calibration curves of unburned carbon, and also for the precision and accuracy of repeat measurements. The analysis results show that the regression coefficients of the calibration curves and the precision and accuracy of repeat measurements are improved by correcting C-Fe interference, especially for the fly ash samples with low level unburned carbon content. However, the choice of the Fe line need to avoid a over-correction for C line. Obviously, Fe 254.60 nm is the best choice for the correction of the C-Fe interference.

参考文献

[1] GUI Liang-ming, MAO Xiao-fei, LI Hai-shan(桂良明, 毛晓飞, 李海山). Power System Engineering(电站系统工程), 2014, 30(2): 37.

[2] Gao Yuming, Kulaots Indrek, Chen Xu, et al. Proceedings of the Combustion Institute, 2002, 29(1): 475.

[3] Pedersen Kim Hougaard, Jensen Anker Degn, Dam-Johansen Kim. Combustion and Flame, 2010, 157(2): 208.

[4] Schneider A, Chabicovsky R, Aumuller A. Sensors and Actuators A, 1998, 67(1-3): 24.

[5] Smith Ken, Dixon Terry, Taylor James. World of Coal Ash Conference, 2009, 1.

[6] NIU Pei-feng, HUA Ke, ZHANG Xian-ping(牛培峰, 化克, 张现平). Chinese Journal of Scientific Instrument(仪器仪表学报), 2009, 30(6): 1207.

[7] CHENG Qi-ming, CHENG Yin-man, WANG Ming-mei, et al(程启明, 程尹曼, 汪明媚, 等). Boiler Technology(锅炉技术), 2011, 42(1): 1.

[8] Melick Todd, Sommer Todd, Conrads Hans. World of Coal Ash/DOE UBC Conference 2005: 1.

[9] WANG Peng, ZHENG Sheng-peng, XIE Hai-long(王鹏, 郑圣鹏, 解海龙). Power Station Auxiliary Equipment(电站辅机), 2012, 33(1), 42.

[10] Noda M, Deguchi Y, Iwasaki S, et al. Spectrochimica Acta Part B, 2002, 57(4): 701.

[11] Kurihara M, Ikeda K, Izawa Y, et al. Applied Optics, 2003, 42: 6159.

[12] WU Ge, LU Ji-dong, YU Liang-ying, et al(吴戈, 陆继东, 余亮英, 等). Journal of Engineering for Thermal Energy and Power(热能动力工程), 2005, 20(4): 365.

[13] YAO Shun-chun, LU Ji-dong, PAN Sheng-hua, et al(姚顺春, 陆继东, 潘圣华, 等). Proceedings of the CSEE(中国电机工程学报), 2009, 29(23): 80.

[14] YAO Shun-chun, LU Ji-dong, PAN Sheng-hua, et al(姚顺春, 陆继东, 潘圣华, 等). Chinese Journal of Lasers(中国激光), 2010, 37(4): 1114.

[15] Yao Shunchun, Lu Jidong, Zheng Jianping, et al. J. Anal. At. Spectrom., 2012, 27(3), 473.

[16] Zhang Lei, Ma Weiguang, Dong Lei, et al. Applied Spectroscopy, 2011, 65(7): 790.

[17] PRC Power Industry Standard(中华人民共和国电力行业标准). DL/T 567.6—95.

[18] ZHENG Guo-jing, JI Zi-hua, YU Xing(郑国经, 计子华, 余兴). Atomic Emission Spectrometry Technology and Application(原子发射光谱分析技术及应用). Beijing: Chemical Industry Press(北京: 化学工业出版社), 2010, 40.

姚顺春, 陈建超, 陆继东, 沈跃良, 潘刚. C-Fe谱线干扰修正对飞灰含碳量LIBS测量的影响[J]. 光谱学与光谱分析, 2015, 35(6): 1719. YAO Shun-chun, CHEN Jian-chao, LU Ji-dong, SHEN Yue-liang, PAN Gang. Influence of C-Fe Lines Interference Correction on Laser-Induced Breakdown Spectroscopy Measurement of Unburned Carbon in Fly Ash[J]. Spectroscopy and Spectral Analysis, 2015, 35(6): 1719.

C-Fe谱线干扰修正对飞灰含碳量LIBS测量的影响

关于本站 Cookie 的使用提示

全站搜索

C-Fe谱线干扰修正对飞灰含碳量LIBS测量的影响

相关论文

相关资讯

关于本站 Cookie 的使用提示

全站搜索