中国激光, 2009, 36 (s1): 147, 网络出版: 2009-06-18   

K418涡轮盘与42CrMo涡轮轴异种金属激光焊接

Dissimilar Metal Laser Welding of Cast Ni-Based Superalloy K418 Turbo Disk and Alloy Steel 42CrMo Shaft
作者单位
1 中国北方发动机研究所分所, 河北 廊坊 065000
2 中国科学院力学研究所, 北京 100080
摘要
研究了镍基高温合金(K418)涡轮盘与合金钢(42CrMo)轴异种金属的激光焊接。通过光学显微镜(OM)、扫描电镜(SEM)分析了焊缝区域组织。结果表明, 侧吹保护气流量大, 焊缝收尾处易形成鼓包缺陷; 由于K418与42CrMo热物性的差异, 焊缝易偏向K418且焊缝与K418交界易剥离; 焊缝与母材交界组织为具有一定方向的枝晶组织。在扫描电镜下焊缝区域观察到了颗粒状的Laves相。由于K418和42CrMo混合比例和冷却速度的差异导致焊缝不同区域颗粒状的Laves相的致密度不同。
Abstract
Dissimilar metal laser welding of cast Ni-based superalloy K418 turbo disk and alloy steel 42CrMo shaft was studied. Microstructure of the welded seam was characterized by optical microscopy (OM) and scanning electron microscopy (SEM). Results showed that side-blow shielding gas was warped in the melt pool with excessive flow rate of shielding gas by progressively reducing of heat input of laser. Bubble defect of seam ending can be inhibited by optimizing flow rate of side-blow shielding gas. Microstructure of the weld and base metal interface is mainly composed of dendrites whose growing direction is nearly parallel to the negative heat-transfer direction. Distribution of Laves phase have discrepancy in different region of the welded seam because of different mixing proportion of K418 and 42CrMo,and different solidifying velocity in different region of the melting pool.
参考文献

[1] . W. Lee. Inertia friction welding of a gas turbine rotor[J]. Welding Review International, 1992, 11(4): 189-192.

[2] . .Boundary liquation and interface cracking characterization in laser deposition of Inconel 738 on directionally solidified Ni-based superalloy[J]. Scripta Materialia, 2005, 53(2): 159-164.

[3] 熊建钢, 胡席远, 陈祖涛 等. 激光焊接铸造镍基高温合金工艺研究[J]. 中国激光, 1996, A23(12): 1107~1111

    Xiong Jiangang, Hu Xiyuan, Chen Zutao et al.. Study on laser welding of cast nickel-base superalloy[J]. Chinese J. Lasers, 1996, A23(12): 1107~1111

[4] 庞铭, 虞钢, 刘兆 等. K418与42CrMo异种金属的激光穿透焊接[J]. 中国激光, 2006, 33(8): 1122~1126

    Pang Ming, Yu Gang, Liu Zhao et al.. Dissimilar metal of K418 and 42CrMo full penetration laser welding[J]. Chinese J. Lasers, 2006, 33(8): 1122~1126

[5] . K418涡轮盘和42CrMo轴摩擦焊接头的强化[J]. 西北工业大学学报, 2004, 22(1): 112-115.

    . . Strengthening of the friction welding joint between K418 turbo disk and 42CrMo shaft[J]. Journal of Northwestern Polytechnical University, 2004, 22(1): 112-115.

[6] 孙同坤. 1 mm薄钢板激光焊接实验研究[J]. 中国激光, 1993, A20(12): 936~939

    Sun Tongkun. Experimental research on laser welding of 1 mm steel sheet[J]. Chinese J. Lasers, 1993, A20(12): 936~939

[7] 虞钢, 赵树森, 张永杰 等. 异种金属激光焊接关键问题研究[J]. 中国激光, 2009, 36(2): 261~268

    Yu Gang, Zhao Shusen, Zhang Yongjie et al.. Research on key Lssues of laser welding of dissimilar metal[J]. Chinese J. Lasers, 2009, 36(2): 261~268

[8] 李俐群, 陈彦宾, 陶汪. 铝合金双光束焊接特性研究[J]. 中国激光, 2008, 35(11): 1783~1788

    Li Liqun, Chen Yanbin, Tao Wang. Research on dual-beam welding characteristics of aluminum alloy[J]. Chinese J. Lasers, 2008, 35(11): 1783~1788

[9] 许良红, 田志凌, 彭云 等. 高强铝合金的激光焊接头组织与力学性能[J]. 中国激光, 2008, 35(3):456~461

    Xu Lianghong, Tian Zhiling, Peng Yun et al.. Microstructure and mechanical properties of high strength aluminum alloy laser welds[J]. Chinese J. Lasers, 2008, 35(3):456~461

[10] 魏华凯, 孙福娟. Al-Mg-Sc与2A12激光对焊工艺[J]. 中国激光, 2008, 35(10): 1615~1618

    Wei Huakai, Sun Fujuan. Technology of laser welding on Al-Mg-Sc and 2A12[J]. Chinese J. Lasers, 2008, 35(10): 1615~1618

[11] 孙福娟, 刘洪军, 胡芳友. 激光表面重熔对LY12CZ性能的影响[J]. 中国激光, 2007, 34(8): 1159~1162

    Sun Fujuan, Liu Hongjun, Hu Fangyou. Effect of laser surface remelting on performance of LY12CZ[J]. Chinese J. Lasers, 2007, 34(8): 1159~1162

[12] 张盛海, 陈凯, 肖荣诗 等. 铝合金高功率CO2激光粉末焊接[J]. 中国激光, 2006, 33(5): 714~718

    Zhang Shenghai, Chen Kai, Xiao Rongshi et al.. High power CO2 laser powder welding of aluminum alloy[J]. Chinese J. Lasers, 2006, 33(5): 714~718

[13] . K418与42CrMo异种金属激光深熔焊接[J]. 焊接学报, 2007, 28(9): 83-86.

    . . Deep penetration laser welding dissimilar metal of K418 and 42CrMo[J]. Transactions of the China Welding Institution, 2007, 28(9): 83-86.

[14] . K418与42CrMo异种金属激光焊接接头组织与力学性能[J]. 焊接学报, 2008, 29(2): 85-88.

    . . Microstructure and mechanical properties of K418 and 42CrMo dissimilar metal laser welding[J]. Transactions of the China Welding Institution, 2008, 29(2): 85-88.

[15] Liu Xiubo, Pang Ming, Huang Jianguo et al.. Transmission electron microscopy characterization of laser welding cast Ni-based superalloy K418 turbo disk and alloy steel 42CrMo shaft[J]. Journal of Alloys and Compounds, 2008, 461(1~2): 648~653

庞铭, 谭建松, 王建平, 吴波, 解志民, 胡定云, 虞钢. K418涡轮盘与42CrMo涡轮轴异种金属激光焊接[J]. 中国激光, 2009, 36(s1): 147. Pan Ming, Tan Jiansong, Wang Jianping, Wu Bo, Xie Zhimin, Hu Dingyun, Yu Gang. Dissimilar Metal Laser Welding of Cast Ni-Based Superalloy K418 Turbo Disk and Alloy Steel 42CrMo Shaft[J]. Chinese Journal of Lasers, 2009, 36(s1): 147.

本文已被 1 篇论文引用
被引统计数据来源于中国光学期刊网
引用该论文: TXT   |   EndNote

相关论文

加载中...

关于本站 Cookie 的使用提示

中国光学期刊网使用基于 cookie 的技术来更好地为您提供各项服务,点击此处了解我们的隐私策略。 如您需继续使用本网站,请您授权我们使用本地 cookie 来保存部分信息。
全站搜索
您最值得信赖的光电行业旗舰网络服务平台!