Bi3+或Sm3+掺杂对NaGd(WO4)2∶Eu3+荧光粉结构和发光性质的影响

翟永清; 赵鑫; 杨帅; 孙庆琳; 邓德芮; 胡正磊; 丁士文; 苗曼红

doi:doi:10.3788/fgxb20173808.0987

发光学报, 2017, 38 (8): 987, 网络出版: 2017-08-30

Bi³⁺或Sm³⁺掺杂对NaGd(WO₄)₂∶Eu³⁺荧光粉结构和发光性质的影响

Influence of Bi³⁺ or Sm³⁺ Doping on Structure and Luminescence Properties of NaGd(WO₄)₂∶Eu³⁺ Phosphors

论文大纲

翟永清 ^*赵鑫杨帅孙庆琳邓德芮胡正磊丁士文苗曼红

作者单位

河北大学化学与环境科学学院, 河北保定071002

红色荧光粉水热法 Bi3+和Sm3+ 敏化发光 NaGd(WO4)2 NaGd(WO4)2 red phosphor hydrothermal method Bi3+ and Sm3+ sensitized luminescence

摘要

采用水热法制备了白光LED用NaGd0.95-x(WO4)2∶0.05Eu3+,xBi3+(x=0, 0.02, 0.04, 0.06, 0.08)和NaGd0.95-y(WO4)2∶0.05Eu3+,ySm3+(y=0, 0.01, 0.02, 0.03, 0.04)系列红色荧光粉, 通过X射线衍射仪、扫描电子显微镜及荧光分光光度计等表征手段分析了样品的物相结构、颗粒形貌以及发光性质。结果表明: 少量离子掺杂对NaGd(WO4)2的晶体结构影响较小, 样品均为四方晶系、白钨矿结构的纯相; 颗粒形貌呈四方盘状, 且粒度均匀, 分散性良好, Bi3+或Sm3+的引入使颗粒尺寸由原来的4 μm分别增加至5 μm和6 μm。该系列荧光粉均可被近紫外光(394 nm)有效激发, 其最强发射峰位于614 nm处, 归属于Eu3+的5D0→7F2电偶极跃迁。掺杂适量的Bi3+或Sm3+可有效提高NaGd0.95(WO4)2∶0.05Eu3+荧光粉的发光强度和红光的色纯度, 其中Sm3+的引入对其影响更为明显。

Abstract

A series of red phosphors NaGd0.95-x(WO4)2∶0.05Eu3+,xBi3+(x=0, 0.02, 0.04, 0.06, 0.08)and NaGd0.95-y(WO4)2∶0.05Eu3+,ySm3+(y=0, 0.01, 0.02, 0.03, 0.04)were synthesized via hydrothermal process. The structure, morphology and luminescent properties of the samples were characterized by X-ray diffraction, scanning electron microscope and fluorescence spectrophotometer, respectively. The results indicate that the crystal structure of NaGd(WO4)2 is almost not changed by doping a small amount of ions, and all samples are tetragonal scheelite-type pure phase. The particles are square plate in shape, relatively uniform and well dispersive. With the introduction of Bi3+ or Sm3+, the particle size increases from the original 4 μm to 5 μm and 6 μm, respectively. The series of phosphors can be effectively excited under near-UV (at 394 nm), and the strongest emission peak is located at 614 nm which corresponds to the 5D0→7F2 transition of Eu3+. In addition, doping with an appropriate amount of Bi3+ or Sm3+ can improve the luminescence intensity and red-light purity of NaGd0.95(WO4)2∶0.05Eu3+ phosphors, especially for Sm3+.

参考文献

[1] ZHANG Y, GONG W T, YU J J, et al.. Multi-color luminescence properties and energy transfer behaviour in host-sensitized CaWO4∶ Tb3+, Eu3+ phosphors ［J］. RSC Adv., 2016, 6(37):30886-30894.

[2] ZHANG Y, GONG W T, YU J J, et al.. Tunable white-light emission via energy transfer in single-phase LiGd(WO4)2∶Re3+ (Re=Tm, Tb, Dy, Eu) phosphors for UV-excited WLEDs ［J］. RSC Adv., 2015, 5(117):96272-96280.

[3] LI L L, LIU Y L, LI R Q, et al.. Tunable luminescence properties of the novel Tm3+- and Dy3+-codoped LiLa(MoO4)x-(WO4)2-x phosphors for white light-emitting diodes ［J］. RSC Adv., 2015, 5(10):7049-7057.

[4] LI L L, LIU L, ZI W W, et al.. Synthesis and luminescent properties of high brightness MLa(WO4)2∶Eu3+ (M=Li, Na, K) and NaRE(WO4)2∶Eu3+ (RE=Gd, Y, Lu) red phosphors ［J］. J. Lumin., 2013, 143:14-20.

[5] BI W B, MENG Q Y, SUN W J. Luminescent properties and energy transfer mechanism of NaGd(MoO4)2∶Sm3+, Eu3+ phosphors ［J］. Ceram. Int., 2016, 42(12):14086-14093.

[6] QIN D, TANG W J. Energy transfer and multicolor emission in single-phase Na5Ln(WO4)4-z(MoO4)z∶Tb3+, Eu3+ (Ln=La, Y, Gd) phosphors ［J］. RSC Adv., 2016, 6(51):45376-45385.

[7] ZHAI Y Q, WANG M, ZHAO Q, et al.. Fabrication and luminescent properties of ZnWO4∶Eu3+, Dy3+ white light-emitting phosphors ［J］. J. Lumin., 2016, 172:161-167.

[8] 李云青, 崔彩娥, 黄平, 等. Pr3+, Yb3+双掺的CaWO4荧光粉的近红外量子剪裁［J］. 光子学报, 2015, 44(7):0716001.

LI Y Q, CUI C E, HUANG P, et al.. Near infrared quantum cutting in Pr3+, Yb3+ co-doped CaWO4 phosphors ［J］. Acta Photon. Sinica, 2015, 44(7):0716001. (in Chinese)

[9] RASU K K, BALAJI D, BABU S M. Photoluminescence properties of Eu3+∶RbGd(WO4)2 red phosphors prepared by sol-gel method ［J］. J. Lumin., 2016, 170:825-834.

[10] SHI P L, XIA Z G, MOLOKEEV M S, et al.. Crystal chemistry and luminescence properties of red-emitting CsGd1-xEux-(MoO4)2 solid-solution phosphors ［J］. Dalton Trans., 2014, 43(25):9669-9676.

[11] BALAJI D, DURAIRAJAN A, RASU K K, et al.. Sol-gel synthesis and luminescent properties of Eu3+∶ CsGd(WO4)2 red emitting phosphors ［J］. J. Lumin., 2014, 146:458-463.

[12] 耿秀娟, 杨旭, 李梓杨, 等. Eu3+-Bi3+共掺杂Ca0.7Sr0.3MoO4荧光粉发光性能的研究［J］. 光电子·激光, 2015, 26(5):905-909.

GENG X J, YANG X, LI Z Y, et al.. Luminescence investigation of Eu3+-Bi3+ co-doped Ca0.7Sr0.3MoO4 phosphor ［J］. J. Optoelectron. Laser, 2015, 26(5):905-909. (in Chinese)

[13] YU P S, SU L B, XU J. Synthesis and luminescence properties of Eu3+, Bi3+_doped BaWO4 phosphors ［J］. Opt. Rev., 2014, 21(4):455-460.

[14] LI L L, LENG Z H, ZI W W, et al.. Hydrothermal synthesis of SrMoO4∶ Eu3+, Sm3+ phosphors and their enhanced luminescent properties through energy transfer ［J］. J. Electron. Mater., 2014, 43(7):2588-2596.

[15] LIU Y, LIU G X, DONG X T, et al.. Luminescence, energy-transfer and tunable color properties of single-component Tb3+ and/or Sm3+ doped NaGd(WO4)2 phosphors with UV excitation for use as WLEDs ［J］. RSC Adv., 2014, 4(102):58708-58716.

[16] LIU T, MENG Q Y, SUN W J. Luminescent properties of Eu3+ doped NaY(WO4)2 nanophosphors prepared by molten salt method ［J］. J. Rare Earths, 2015, 33(9):915-921.

[17] YANG X M, TANG H X, GUO Z F. Morphology-controlled synthesis of NaGd(WO4)2∶Eu3+ microcrystals by hydrothermal process ［J］. Superlatt. Microstruct., 2015, 80:188-195.

[18] 章少华, 江柳杨, 张璟, 等. Bi3+掺杂对Sr2MgSi2O7∶Eu2+荧光粉的结构及发光性能的影响［J］. 发光学报, 2012, 33(8):824-827.

ZHANG S H, JIANG L Y, ZHANG J, et al.. Effects of Bi3+ concentration on luminescent properties of Sr2MgSi2O7∶Eu2+ phosphor ［J］. Chin. J. Lumin., 2012, 33(8):824-827. (in Chinese)

[19] SHI Y R, LIU B T, LIU B, et al.. Enhanced red emission in Ca0.5La(MoO4)2∶Eu3+ phosphors for UV LEDs ［J］. RSC Adv., 2015, 5(116):95953-95959.

[20] MO F W, ZHOU L Y, PANG Q, et al.. Potential red-emitting NaGd(MO4)2∶R (M=W, Mo, R=Eu3+, Sm3+, Bi3+) phosphors for white light emitting diodes applications ［J］. Ceram. Int., 2012, 38(8):6289-6294.

[21] 黄维刚, 李磊. Bi3+掺杂蓝色荧光粉GdVO4∶Tm3+的发光性能［J］. 稀有金属材料与工程, 2014, 43(2):391-394.

HUANG W G, LI L. Luminescence properties of Bi3+-doped GdVO4∶Tm3+ blue phosphors ［J］. Rare Metal Mater. Eng., 2014, 43(2):391-394. (in Chinese)

[22] 关荣锋, 孙倩, 李勤勤, 等. CaMoO4∶Eu3+, Bi3+, Li+红色荧光粉的共沉淀制备与表征［J］. 发光学报, 2013, 34(8):1000-1005.

GUAN R F, SUN Q, LI Q Q, et al.. Co-precipitation synthesis and characterization of CaMoO4∶Eu3+, Bi3+, Li+ red phosphor ［J］. Chin. J. Lumin., 2013, 34(8):1000-1005. (in Chinese)

[23] ZHAI Y Q, ZHANG W, YIN Y J, et al.. Morphology tunable synthesis and luminescence property of NaGd(MoO4)2∶Sm3+ microcrystals ［J］. Ceram. Int., 2017, 43(1):841-846.

[24] 杨志平, 梁晓双, 赵引红, 等. 橙红色荧光粉Ca3Y2(Si3O9)2∶Sm3+的制备及发光性能的表征［J］. 光子学报, 2014, 43(3):0316002.

YANG Z P, LIANG X S, ZHAO Y H, et al.. Preparation and luminescence properties of reddish-orange phosphors Ca3Y2(Si3O9)2∶Sm3+ ［J］. Acta Photon. Sinica, 2014, 43(3):0316002. (in Chinese)

[25] JIN Y, HAO Z D, ZHANG X, et al.. Dynamical processes of energy transfer in red emitting phosphor CaMoO4∶Sm3+, Eu3+ ［J］. Opt. Mater., 2011, 33(11):1591-1594.

[26] LIU X G, LI L, NOH H M, et al.. Controllable synthesis of uniform CaMoO4∶Eu3+, M+ (M=Li, Na, K) microspheres and optimum luminescence properties ［J］. RSC Adv., 2015, 5(13):9441-9454.

翟永清, 赵鑫, 杨帅, 孙庆琳, 邓德芮, 胡正磊, 丁士文, 苗曼红. Bi³⁺或Sm³⁺掺杂对NaGd(WO₄)₂∶Eu³⁺荧光粉结构和发光性质的影响[J]. 发光学报, 2017, 38(8): 987. ZHAI Yong-qing, ZHAO Xin, YANG Shuai, SUN Qing-lin, DENG De-rui, HU Zheng-lei, DING Shi-wen, MIAO Man-hong. Influence of Bi³⁺ or Sm³⁺ Doping on Structure and Luminescence Properties of NaGd(WO₄)₂∶Eu³⁺ Phosphors[J]. Chinese Journal of Luminescence, 2017, 38(8): 987.

Bi³⁺或Sm³⁺掺杂对NaGd(WO₄)₂∶Eu³⁺荧光粉结构和发光性质的影响

关于本站 Cookie 的使用提示

全站搜索